Bryant ASPAX1BBA015 Uživatelský manuál

Installation andOwner’s ManualAir-cooled AutomaticStandby GeneratorsModel: ASPAX1BBA015(13 kW NG, 15 kW LP)DANGERDEADLY EXHAUST FUMES. OUTDOOR INSTALL

1.10.2 TRANSFER SWITCH1.10.2.1 15 kW UnitsTransfer switches for use with this generator are sold separately and can be purchased from dealers.• Inst

The following procedures are to be observed:• Wear full eye protection and protective clothing;• Where electrolyte contacts the skin, wash it off imm

DANGER Proceed with caution! Generator power voltage is now supplied to the transfer switch. Contact with live transfer switch parts will result in

With the generator running and loads powered by generator AC output, turn ON the utility power supply to the transfer switch. The following should occ

2.7 ENGINE GOVERNOR ADJUSTMENTIf both AC frequency and voltage are correspondingly high or low, adjust the engine governor as follows:2.7.1 15 KW UN

9. Allow the unit to cool.10. Set the generator’s main circuit breaker to its OFF (or OPEN) position.11. Set the generator's AUTO/OFF/MANUAL swi

Section 3 — Operation15 kW Generator3.3.2 120 VAC GFCI OUTLETThe generator is equipped with an external 15 amp, 120 volt, GFCI convenience outlet tha

5. To crank and start the engine, set the AUTO/OFF/ MANUAL switch to MANUAL.6. Let the engine stabilize and warm up for a few minutes.7. Set the ge

3.7.3 OVERCRANKThis feature prevents the generator from damaging itself when it continually attempts to start and anoth-er problem, such as no fuel su

 Any attempt to crank or start the engine before it has been properly serviced with the recom-mended oil may result in an engine failure.4.3.2 OIL

INTRODUCTIONThank you for purchasing this model of the Bryant product line. This model is a compact, high perfor-mance, air-cooled, engine-driven gene

Figure 4.5 – Setting the Spark Plug Gap4.7 BATTERY MAINTENANCEThe battery should be inspected per the “Service Schedule”. The following procedure shou

• Make sure the piston is at Top Dead Center (TDC) of its compression stroke (both valves closed). To get the piston at TDC, remove the intake screen

4.12 OUT OF SERVICE PROCEDURE4.12.1 REMOVAL FROM SERVICEIf the generator cannot be exercised every seven days, and will be out of service longer tha

Section 4 — Maintenance15 kW Generator 214.13 SERVICE SCHEDULEATTENTION: It is recommended that all service work be performed by the nearest dealer

Section 5 — Troubleshooting 15 kW Generator5.1 TROUBLESHOOTING GUIDEProblem Cause CorrectionThe engine will not crank. 1. Fuse blown 1. Replac

23Section 6 — Mounting Dimensions15 kW GeneratorDrawing No. 0D3739-BTM6PEM-TM6PM6PEMPEREAR VIEWLEFT SIDE VIEWTRANSFER SWITCHRIGHT SIDE VIEWFRONT VIE

TX - TRANSFORMER, 16 Vac 56 VA & 16 Vac 1 VA (DUAL SEC.)BLACKCUSTOMER SUPPLIEDBATTERY12V0SP2SP1IM2LOP0HTO8685IM1DDBCR - BATTERY CHARGE RELAYCB1 -

GRD194224224225152242254224B225B142250013CLOSEST TO BEARINGOUTPUT TO TRANSFER2222MANUALF212VDC ACCESSORY SOCKET15B+015A66A23915-0F11515151313151717VOL

CHARGERBATTERYTX - TRANSFORMER, 16 Vac 56 VA & 16 Vac 1 VA (DUAL SEC.)0DIAGRAM KEYBA - BRUSH ASSEMBLYSCR - STARTER CONTACTOR RELAYSC - STARTER CON

F1SMC1-115018C1-5561817151715ASCR000151623915140194231318DIM2IM1SP2SP12316013SC0SW11515A239194FS014C2-1WINDING(STATOR)POWER224411CB13356VA1VA13225225A

1Table of Contents15 kW GeneratorIntroduction ...Inside Front Cover Read This Manual Thoroughly ... IFC C

35684952PRE PACKAGED UNITS ONLY20249464343373325353426747779354982805146880472875867648399218949163211551714269105249355149113195099987246415727911565

ITEM PART NO. QTY. DESCRIPTION 1 0C6140 1 ASSEMBLY, ENCLOSURE BASE 0D1901 1 ASSEMBLY, ENCLOSURE BASE (7KW) 2 0C6735 2 SUPPORT, ROOF FOLDING 3

Section 8 — Exploded Views and Parts Lists15 kW GeneratorControl Panel – Drawing No. 0E9162-J 30

ITEM PART NO. QTY. DESCRIPTION 1 0E7886A 1 CIRCUIT BREAKER 30A X 2P 240V (7KW) 0E7886E 1 CIRCUIT BREAKER 50A X 2P 240V (12KW) 0E7886J 1 CIR

14347, 48, 49, 50, 51, 52, 53, 54, 56, 57, 58, 59, 60, 62, 63, 647, 47, 48, 49, 50, 51, 52, 53, 54, 56, 57, 58, 59, 60, 63, 64144534648474950515240384

ITEM PART NO. QTY. DESCRIPTION 1 0C5729 1 ASSEMBLY, CRANKCASE HOUSING WITH SLEEVE 2 0E9843 1 SEAL, 38 I.D. CRANKSHAFT 3 090388 3 SCREW, TAPTIT

34 1121121281101339491848886898590899374808283817911710299929798101113112105107108104103106111109143125123, 14596951431301147578777699100118989712112

35ITEM PART NO. QTY. DESCRIPTION 74 0C5136A 2 KNOB, AIR CLEANER 75 0C3024 1 COVER, AIRBOX NG/LP 76 0C3040 1 PRE-CLEANER, 77 0C8127 1 ELEMENT, A

2936341123524432171333123817323128312019101715321622394986371432401322425103019262827283231411018362835412942363635Section 8 — Exploded Views and Part

Section 8 — Exploded Views and Parts Lists15 kW Generator15 kW Generator – Drawing No. 0D3417-LITEM PART NO. QTY. DESCRIPTION 1 0C6934 1 ADAPTOR, E

2 Study these SAFETY RULES carefully before installing,operating or servicing this equipment. Become familiar with this Owner’s Manual and with the u

17122811201032252124192322221526141316291828121011273145321017126151416133719930212520242918231112288Section 8 — Exploded Views and Parts Lists15 kW G

ITEM PART NO. QTY. DESCRIPTION 1 0D5694 1 CASTING, TWIN REGULATOR HOUSING 2 0F5022 1 SOLENOID COIL, 12VDC 3 0C4647 1 GASKET , SOLENOID 4 0D

Section 9 – Warranty15 kW GeneratorNOTE: This Emission Control Warranty Statement pertains to this product only IF the generator size is 15 kW or belo

Section 9 – Warranty15 kW GeneratorEMISSION CONTROL SYSTEM WARRANTYEmission Control System Warranty (ECS Warranty) for 1997 and later model year engin

Section 9 – Warranty15 kW GeneratorPart No. 0F7614 Rev. 0 (08/24/05) Printed in U.S.A.Catalog No. OM18-7BRYANT "TWO YEAR" LIMITED WARRANTY F

be done around an operating unit, stand on an insulated, dry surface to reduce shock hazard.• Do not handle any kind of electrical device while standi

DANGER Only qualified electricians or contractors should attempt such installations, which must comply strictly with applicable codes, standards and

Section 1 — General Information15 kW Generator1.5 THE GENERATORExhaustEnclosureOil FilterBatteryCompartmentFuelInletGFCIOutletControlPanelDataDecalO

Section 1 — General Information15 kW Generator 6 1.6 SPECIFICATIONS1.6.1 GENERATORRated Max. Cont. Power Capacity (Watts*) ... 13,000 NG/15,000 L

1.9 RECONFIGURING THEFUEL SYSTEM1.9.1 15KW, 990CC ENGINESTo reconfigure the fuel system from NG to LP, follow these steps:NOTE:The primary regulator